Heat & Mass Transfer 1000+ MCQ with answer for RBI Grade B officer

1. The total emissivity power is .defined as the total amount of radiation emitted by a black body per unit
A. Temperature
B. Thickness
C. Area
D. Time
Answer : D

2. A non-dimensional number generally associated with natural convection heat transfer is
A. Grashoff number
B. Nusselt number
C. Weber number
D. Prandtl number
Answer : A

3. Total emissivity of polished silver compared to black body is
A. Same
B. Higher
C. More or less same
D. Very much lower
Answer : D

4. Thermal conductivity of air at room temperature in kcal/m hr °C is of the order of
A. 0.002
B. 0.02
C. 0.01
D. 0.1
Answer : B

5. Sensible heat factor is given by (where S.H. = Sensible heat, and L.H. = Latent heat)
A. S.H/(S.H + L.H)
B. (S.H + L.H) /S.H
C. (L.H - S.H)/S.H
D. S.H/(L.H - S.H)
Answer : A

6. A steam pipe is to be lined with two layers of insulating materials of different thermal conductivities. For the minimum heat transfer,
A. The better insulation must be put inside
B. The better insulation must be put outside
C. One could place either insulation on either side
D. One should take into account the steam temperature before deciding as to which insulation is put where
Answer : A

7. The unit of Stefan-Boltzmann constant is
A. Watt/mK
B. Watt/m²K²
C. Watt/m²K⁴
D. Watt/mK²
Answer : C

8. Log mean temperature difference in case of counter flow compared to parallel flow will be
A. Same
B. More
C. Less
D. Depends on other factors
Answer : B

9. The thermal diffusivities for gases are generally
A. More than those for liquids
B. Less than those for liquids
C. More than those for solids
D. Dependent on the viscosity
Answer : A

10. Free convection flow depends on
A. Density
B. Coefficient of viscosity
C. Gravitational force
D. All of these
Answer : D

11. Stefan Boltzmann law is applicable for heat transfer by
A. Conduction
B. Convection
C. Radiation
D. Conduction and radiation combined
Answer : C

12. The emissive power of a body depends upon its
A. Temperature
B. Wave length
C. Physical nature
D. All of the above
Answer : D

13. Two balls of same material and finish have their diameters in the ratio of 2: 1 and both are heated to same temperature and allowed to cool by radiation. Rate of cooling by big ball as compared to smaller one will be in the ratio of
A. 1 : 1
B. 2 : 1
C. 1 : 2
D. 4 : 1
Answer : C

14. Which of the following has least value of conductivity?
A. Glass
B. Water
C. Plastic
D. Air
Answer : D

15. Which of the following has maximum value of thermal conductivity?
A. Aluminium
B. Steel
C. Brass
D. Copper
Answer : A

16. The most commonly used method for the design of duct size is the
A. Velocity reduction method
B. Equal friction method
C. Static regains method
D. Dual or double method
Answer : C

17. The use of heat exchangers is made in
A. Radiators in automobile
B. Condensers and boilers in steam plants
C. Condensers and evaporators in refrigeration and air conditioning units
D. All of the above
Answer : D

18. A composite slab has two layers of different materials with thermal conductivities k? and k?. If each layer has the same thickness, then the equivalent thermal conductivity of the slab will be
A. k? k?
B. (k? + k?)
C. (k? + k?)/ k? k?
D. 2 k? k?/ (k? + k?)
Answer : D

19. Thermal conductivity of water in general with rise in temperature
A. Increases
B. Decreases
C. Remain constant
D. May increase or decrease depending on temperature
Answer : D

20. According to Stefan Boltzmann law, the total radiation from a black body per second per unit area is directly proportional to the
A. Absolute temperature
B. Square of the absolute temperature
C. Cube of the absolute temperature
D. Fourth power of the absolute temperature
Answer : D

21. Heat flows from one body to other when they have
A. Different heat contents
B. Different specific heat
C. Different atomic structure
D. Different temperatures
Answer : D

22. The rate of energy emission from unit surface area through unit solid angle, along a normal to the surface, is known as
A. Emissivity
B. Transmissivity
C. Reflectivity
D. Intensity of radiation
Answer : D

23. The concept of overall coefficient of heat transfer is used in case of heat transfer by
A. Conduction
B. Convection
C. Radiation
D. Conduction and convection
Answer : D

24. The unit of overall coefficient of heat transfer is
A. W/m²K
B. W/m²
C. W/mK
D. W/m
Answer : A

25. The unit of Stefan Boltzmann constant is
A. Watt/cm² °K
B. Watt/cm4 °K
C. Watt²/cm °K?
D. Watt/cm² °K?
Answer : D

26. The heat transfer by conduction through a thick cylinder (Q) is given by (where T? = Higher temperature, T? = Lower temperature, r? = Inside radius, r? = Outside radius, l = Length of cylinder, and k = Thermal conductivity)
A. Q = [2?lk (T? - T?)]/2.3 log (r?/r?)
B. Q = 2.3 log (r?/r?)/[2?lk (T? - T?)]
C. Q = [2? (T? - T?)]/2.3 lk log (r?/r?)
D. Q = = 2?lk/2.3 (T? - T?) log (r?/r?)
Answer : A

27. Fourier's law of heat conduction is (where Q = Amount of heat flow through the body in unit time, A = Surface area of heat flow, taken at right angles to the direction of heat flow, dT = Temperature difference on the two faces of the body, dx = Thickness of the body, through which the heat flows, taken along the direction of heat flow, and k = Thermal conductivity of the body)
A. k. A. (dT/dx)
B. k. A. (dx/dT)
C. k. (dT/dx)
D. k. (dx/dT)
Answer : A

28. The emissivity for a black body is
A. 0
B. 0.5
C. 0.75
D. 1
Answer : D

29. Thermal conductivity of wood depends on
A. Moisture
B. Density
C. Temperature
D. All of the above
Answer : D

30. According of Kirchhoff's law
A. Radiant heat is proportional to fourth power of absolute temperature
B. Emissive power depends on temperature
C. Emissive power and absorptivity are constant for all bodies
D. Ratio of emissive power to absorptive power for all bodies is same and is equal to the emissive power of a perfectly black body.
Answer : D

31. Conduction is a process of heat transfer
A. From one particle of the body to another without the actual motion of the particles
B. From one particle of the body to another by the actual motion of the heated particles
C. From a hot body to a cold body, in a straight line, without affecting the intervening medium
D. None of the above
Answer : A

32. In heat transfer, conductance equals conductivity (kcal/hr/sq.m/ °C/cm) divided by
A. Hr (time)
B. Sq. m (area)
C. °C (temperature)
D. K.cal (heat)
Answer : D

33. A grey body is one whose absorptivity
A. Varies with temperature
B. Varies with wavelength of the incident ray
C. Is equal to its emissivity
D. Does not vary with temperature and. wavelength of the incident ray
Answer : C

34. A cube at high temperature is immersed in a constant temperature bath. It loses heat from its top, bottom and side surfaces with heat transfer coefficients of h?, h? and h? respectively. The average heat transfer coefficient for the cube is
A. h? + h? + h?
B. (h?.h?.h?)1/3
C. 1/h? + 1/h? + 1/h?
D. None of these
Answer : D

35. The heat is transferred by conduction, convection and radiation in
A. Melting of ice
B. Boiler furnaces
C. Condensation of steam in condenser
D. None of these
Answer : B

36. Radiation is the process of heat transfer in which heat flows from a ________, in a straight line, without affecting the intervening medium.
A. Cold body to hot body
B. Hot body to cold body
C. Smaller body to larger body
D. Larger body to smaller body
Answer : B

37. In free convection heat transfer transition from laminar to turbulent flow is governed by the critical value of the
A. Reynold's number
B. Grashoff's number
C. Reynold's number, Grashoff's number
D. Prandtl number, Grashoff's number
Answer : D

38. A grey body is one whose absorptivity
A. Varies with temperature
B. Varies with the wave length of incident ray
C. Varies with both
D. Does not vary with temperature and wave length of the incident ray
Answer : D

39. Fourier's law of heat conduction is valid for
A. One dimensional cases only
B. Two dimensional cases only
C. Three dimensional cases only
D. Regular surfaces having non-uniform temperature gradients
Answer : A

40. Thermal conductivity of air with rise in temperature
A. Increases
B. Decreases
C. Remain constant
D. May increase or decrease depending on temperature
Answer : A

41. Kirchhoff's law states that
A. The total radiation from a black body per second per unit area is directly proportional to the fourth power of the absolute temperature
B. The wave length corresponding to the maximum energy is proportional to the absolute temperature
C. The ratio of the emissive power and absorptive power of all bodies is the same and is equal to the emissive power of a perfectly black body
D. None of the above
Answer : C

42. Reynolds number (RN) is given by (where h = Film coefficient, l = Linear dimension, V = Velocity of fluid, k = Thermal conductivity, t = Temperature, ? = Density of fluid, cp = Specific heat at constant pressure, and ? = Coefficient of absolute viscosity)
A. RN = hl/k
B. RN = ? cp/k
C. RN = ? V l /?
D. RN = V²/t.cp
Answer : C

43. In convection heat transfer from hot flue gases to water tube, even though flow may be turbulent, a laminar flow region (boundary layer of film) exists close to the tube. The heat transfer through this film takes place by
A. Convection
B. Radiation
C. Conduction
D. Both convection and conduction
Answer : C

44. Heat transfer in liquid and gases takes place by
A. Conduction
B. Convection
C. Radiation
D. Conduction and convection
Answer : B

45. The process of heat transfer from one particle of the body to another by the actual motion of the heated particles, is called
A. Conduction
B. Convection
C. Radiation
D. None of these
Answer : B

46. The insulation ability of an insulator with the presence of moisture would
A. Increase
B. Decrease
C. Remain unaffected
D. May increase/decrease depending on temperature and thickness of insulation
Answer : B

47. The ratio of the thickness of thermal boundary layer to the thickness of hydrodynamic boundary layer is equal to (Prandtl number) n, where n is equal to
A. -1/3
B. -2/3
C. 1
D. -1
Answer : A

48. Thermal conductivity of solid metals with rise in temperature normally
A. Increases
B. Decreases
C. Remain constant
D. May increase or decrease depending on temperature
Answer : B

49. Thermal diffusivity is
A. A dimensionless parameter
B. Function of temperature
C. Used as mathematical model
D. A physical property of the material
Answer : D

50. When absorptivity (?) = 1, reflectivity (?) = 0 and transmissivity (?) = 0, then the body is said to be a
A. Black body
B. Grey body
C. Opaque body
D. White body
Answer : A